DTRO garbage leachate processing complete sets of equipment

Product Description

Product introduction: 1.

1.1 garbage leachate treatment technology and future trend of development of the market

1.2 process analysis and comparison

process

UASB + A/O + MBR + NFRO

DTRO

Grille + + ion exchange

Process complexity

The main process seven processing units

The main process three processing units

The main process three processing units

The characteristics of

Affected by the climate of water quality, need to adjust each unit according to situation. Especially in the A/O + MBR system with five units, three reflow units, each unit coordination to A higher level of technology, water production rate is *0%, strong water rate is *0%, emissions can be up to standard

German technology, overcomes the drawback of volume type reverse osmosis easy plugging, without anaerobic aerobic beforehand

Treatment, stable water quality recovery rate can reach *0%, can be up to standard

2. Characteristics of the equipment:

Disk tubular reverse osmosis membrane compared with other membrane components (volume encapsulation), disk tubular reverse osmosis has the following three obvious characteristics:

Channel width 2.1: the passage between the diaphragm (guide) is 6 mm, and the encapsulation of volume type membrane module is only 0.2 mm.

2.2 process short: on the surface of the liquid membrane process only 7 cm, and the encapsulation of volume type membrane module is **0 cm.

Line 2.3 turbulence: due to the effect of high voltage, leachate after the salient points of the guide plate forming high-speed turbulent flow, the turbulence, under the scour of the membrane surface subsidence of pollutants. In volume type encapsulated membrane module, mesh scaffolds can intercept pollutants, causing static water resulting in the pollution of the diaphragm.

The above three characteristics, determines the disc tube reverse osmosis can tolerate high suspended solids SS/SDI/high recovery rate, popular point, mud into the water, is not easy to jam!

2.4 DTRO overcomes the general reverse osmosis system in the treatment of leachate easy jam faults, a cancelled anaerobic aerobic pretreatment, save land resource, maintenance personnel and costs, make the system more stable, lower operation cost. DTRO membrane of normal standard design service life can reach more than 3 years.

3. Process flow diagram:

3.1 the leachate treatment process flow diagram

3.2 process configuration (regions, influent water quality change, design institute of common process options as appropriate)

3.2.1 concentrate to chemical, biochemical - DTRO - emissions

3.2.2 concentrate - hydrolysis acidification - sand filter - level DTRO - secondary DTRO

3.2.3 concentrate to the MBR, the DTRO - emissions

Scope: four.

4.1 garbage recycling waste leachate treatment, living community living garbage leachate treatment, family planning stations, hospitals, epidemic prevention station medical waste leachate treatment, industrial park of garbage leachate treatment, landfill waste leachate treatment.

4.2 domestic landfill leachate treatment, incinerators leachate treatment, life of eat hutch waste plant, coking wastewater treatment, waste water treatment, oil extraction wastewater treatment, chemical wastewater treatment, mobile water purification, desalination processing, recycling separation, acid alkali recovery, recycling, precious metal recovery...